The green hornet TV series featured a 1966 Imperial Crown sedan customized by Dean Jeffries at a cost of US$50,000, part of which went toward the car's paint job: 30 coats of metal flake, pure black green pearl of essence lacquer hand-rubbed to a high gloss. An article in TV Guide published during the show's network run made reference to disparaging comments made within the industry about ABC being "the two-car network" because of the Black Beauty and the Batmobile. The Black Beauty was stored underneath Brit Reid's garage. A set of switches on a secret control panel behind a tool wall would sequentially 1) lower the lights; 2) attach clamps to the axles of Reid's personal car; 3) rotate the floor of the garage – hiding Reid's car and bringing up the Black Beauty; and 4) unclamp the Black Beauty's axles. The Black Beauty would then exit the garage through a hidden rear door, and enter the street from behind a billboard advertising the ficticious product Kissin' Candy Mints – with the slogan "How sweet they are" – that was cleverly designed to separate down the middle and rejoin. The Black Beauty could fire explosive charges from tubes hidden behind retractable panels below the headlights which were said to be rockets with explosive warheads; had a concealed-when-not-in-use, drop-down knock-out gas nozzle in the center of the front grille and the vehicle could launch a small flying video/audio surveillance device (referred to as the scanner) through a small rectangular panel in the middle of the trunk lid. Working "rockets" and "gas nozzles" were incorporated into the trunk lid as well. The TV series employed an audio device from the radio show. In its era, the engines of cheaper cars made a lot of noise; the expensive Pierce-Arrow was reputed to be extremely quiet. So, when the Green Hornet said, "Rig for silent running," the hornet-like buzz on the radio show was turned off and the listener was left to imagine that the car really was silent. On TV, the car sounded like a modern car, but the noise was removed from the soundtrack after this command. The Beauty's regular headlight cluster supposedly could be flipped over to reveal what studio publicity described as "infra-green" headlights. However, the car's headlights were not actually rigged to flip, so the green filters were seen deployed constantly. It was revealed in the related The Green Hornet spin-off Gold Key comic book that the green headlights used polarized light which in combination with the appropriately polarized vision filter (translucent green sun visor-like panels that could be pulled down when needed) could provide almost as much illumination as conventional headlights while being extremely dim – almost invisibly dark – to someone without the filter. In some early episodes in two-shots with both Van Williams and Bruce Lee inside the Black Beauty, as seen through the windshield, Lee's face was tinted green since he was supposedly seen through a "polarized" filter in the form of a large pull-down, transparent green-gray visor; Williams on the other hand was seen in normal light. The tint is not present in close-ups of Lee alone. Since specification of what this lighting was supposed to indicate never actually made it into any finished episode, the effect was unexplained to the audience and soon discontinued. However, most night shots were actually filmed during the daytime by the day for night technique, giving the illusion of night-time as the actual car headlights were not polarized but just had green lenses, which would render the headlights useless for real night-driving. As the series progressed, the process was executed less effectively, reaching the point where the viewer would need context to understand that some scenes were supposed to be taking place at night, as can be observed in screening the episodes in either original network airing or syndication (production) order.
Community content is available under CC-BY-SA unless otherwise noted.